polo power steering problems
-
- Enlisted
- Posts: 4
- Registered for: 12 years 1 month
polo power steering problems
Hi guys can any1 help me with regards to the problem i am experiencing with my power steering on my polo gti.
The power steering light comes on intermitantly and the power steering cuts off, took the car to the dealership they did a diagnostic test and report said that the battery voltage was low, they removed or they charged it and they said the problem was sorted, i drove off 10km later the problem arose again,
any idea what could be the problem, the agents qouted me like 20k to replace a new pump!! could ther be any other problem perhaps, any1 had or having the same problem, any1 advice and help?
The power steering light comes on intermitantly and the power steering cuts off, took the car to the dealership they did a diagnostic test and report said that the battery voltage was low, they removed or they charged it and they said the problem was sorted, i drove off 10km later the problem arose again,
any idea what could be the problem, the agents qouted me like 20k to replace a new pump!! could ther be any other problem perhaps, any1 had or having the same problem, any1 advice and help?
- MeanTdi
- The Imposer Mod-whore-rator
- Posts: 18554
- Registered for: 18 years 1 month
- Car Make: Subaru
- Car Model: WRX
- Membership No: 1153
- Location: JHB
Re: polo power steering problems
Check the earth strap.
Marco
Current: Subaru WRX
Ex: VW Polo 1.9 TDI Sportline
Ex: VW Golf VR6
Ex: VW Golf 1.8 GTi 16v
Current: Subaru WRX
Ex: VW Polo 1.9 TDI Sportline
Ex: VW Golf VR6
Ex: VW Golf 1.8 GTi 16v
ALFAHOLIC wrote:What can go wrong, jarre you guys sound like you are describing an Alfa here...
My Corsa OPC wrote:Its not an oil leak, its just an Opel marking its territory
-
- Enlisted
- Posts: 4
- Registered for: 12 years 1 month
Re: polo power steering problems
ok will do could it be the battery, the pump or the sensors so on
- MeanTdi
- The Imposer Mod-whore-rator
- Posts: 18554
- Registered for: 18 years 1 month
- Car Make: Subaru
- Car Model: WRX
- Membership No: 1153
- Location: JHB
Re: polo power steering problems
Found it:
MeanTdi wrote:Could be the earth strap from the battery to the ground of the car.
Also, have a read here:
MeanTdi wrote:Hi
Have a read here:
http://www.vwclub.co.za/phpbb3/viewtopi ... =3&t=92892
"...replacing the wire to the steering angle sensor!!"
or
"Had a similar problem/gremlin with a few of the polo's I've had and the solution was just to replace the wire/cable from the steering rack to the power steering pump...."
http://www.vwclub.co.za/phpbb3/viewtopi ... r+steering
Marco
Current: Subaru WRX
Ex: VW Polo 1.9 TDI Sportline
Ex: VW Golf VR6
Ex: VW Golf 1.8 GTi 16v
Current: Subaru WRX
Ex: VW Polo 1.9 TDI Sportline
Ex: VW Golf VR6
Ex: VW Golf 1.8 GTi 16v
ALFAHOLIC wrote:What can go wrong, jarre you guys sound like you are describing an Alfa here...
My Corsa OPC wrote:Its not an oil leak, its just an Opel marking its territory
-
- Major
- Posts: 3637
- Registered for: 18 years 7 months
- Car Make: Cheap Ass Porsche
- Car Model: 9N Sooter
- Membership No: 807
- Location: Diep innie bos...
Re: polo power steering problems
http://www.vwclub.co.za/phpbb3/viewtopi ... 3&t=136968
If it's the pump the it will be dead/heavy all the time. Most likely a bad connection somewhere. Bad earth will most likely give other errors too, like ABS etc.
So check the flat fuses on top of the battery and all the sensor cables.
If it's the pump the it will be dead/heavy all the time. Most likely a bad connection somewhere. Bad earth will most likely give other errors too, like ABS etc.
So check the flat fuses on top of the battery and all the sensor cables.
'04 Polo TDI 1661.9 km on 58.05l
'13 Hyundai Santa Fe 2.2 Elite
'13 Hyundai Santa Fe 2.2 Elite
-
- Enlisted
- Posts: 4
- Registered for: 12 years 1 month
Re: polo power steering problems
thnx guys problem sorted, the frikking flat 50amp fuse on the battery was blown, i uesed a "under the tree mac" and he used his launch diagnostic machine and it picked up a fault saying communication error then we checked the fuses on the battery and found that to be blown, all that stress and headache for a simple fuse replacement for R32-00 lol and the agents said i need to replace the pump at a cost of like 20k..............how cud vw not pick that up surprises me hey, thanx guys
- Gforce
- Cadet
- Posts: 754
- Registered for: 17 years 7 months
- Car Make: VW
- Car Model: Polo 6C 1.2TSI
- Membership No: 1711
- Location: JHB
Re: polo power steering problems
I love this forum. Love the search.
Having the exact same issue on the SO's 9n3. I'll check fuses / earth strap etc and revert back.
Thanks kids
Having the exact same issue on the SO's 9n3. I'll check fuses / earth strap etc and revert back.
Thanks kids
________________________________________________
"you can powder coat your arse if you do it right." - MR-D
Current:
2015 Polo 1.2TSI Highline
Ex:
2014 Polo 1.4 Comfortline
2016 Ford Ranger 2.2 XLT Double Cab
2009 A4 2.0T
2004 Golf IV GTi.:R
2003 Golf IV GTI
2006 Fiesta TDCI
2005 Jetta IV 1.8T.:R
2004 Clio Dynamique
2001 Citi Life
"you can powder coat your arse if you do it right." - MR-D
Current:
2015 Polo 1.2TSI Highline
Ex:
2014 Polo 1.4 Comfortline
2016 Ford Ranger 2.2 XLT Double Cab
2009 A4 2.0T
2004 Golf IV GTi.:R
2003 Golf IV GTI
2006 Fiesta TDCI
2005 Jetta IV 1.8T.:R
2004 Clio Dynamique
2001 Citi Life
-
- Cadet
- Posts: 80
- Registered for: 11 years 8 months
- Car Make: VW
- Car Model: polo 9n3 2.0 highline
Re: polo power steering problems
Experienced quiet a similar issue a few months back... even worse my instrument cluster would flash while acoustically beeping and the car would sometimes just cut off... however i had notices some corrosion on the battery positive terminal, i then poured some boiling water and was adviced to apply some grease or vaseline... Guess that got it sorted cause have'nt had the issue for months now...
- conzale
- Enlisted
- Posts: 45
- Registered for: 10 years 1 month
- Car Make: vw
- Car Model: polo 6R
- Location: boksburg/bedfordview/brakpan aka BBB.
Re: polo power steering problems
Same problem on my polo 2010 power steering light is on steering getting hard at slow turns and my mech thinks its the bumo which vw wants me to pay 11k.
a living dog is better than a dead lion
Ex: 2004 mazda 323 1.6i .
Ex: 2004 mazda 323 1.6i .
- Senna
- Captain
- Posts: 2740
- Registered for: 14 years 4 months
- Car Make: VW,BMW
- Car Model: MK5 GTi/CrossCaddy/325iS
- Membership No: 3101
- Location: Gqeberha aka Gwebs
Re: polo power steering problems
I have a Brand new rack for the 6R polos for sale with rack ends if anyone wants one.
- graham savage
- Colonel
- Posts: 5035
- Registered for: 18 years 5 months
- Car Make: VW
- Car Model: Caddy's, Mk2's, Mk4, Ford etc
- Membership No: 803
- Location: Johannesburg
- Contact:
Re: polo power steering problems
Sold one today, R6k inclconzale wrote:Same problem on my polo 2010 power steering light is on steering getting hard at slow turns and my mech thinks its the bumo which vw wants me to pay 11k.
-
- General
- Posts: 9591
- Registered for: 18 years
- Car Make: VW
- Car Model: Golf GT
- Membership No: 1464
- Location: Springs
Re: polo power steering problems
Check the big fuses on top of the battery, they crack through from vibration - I've seen that twice now. The Polo got an electric motor turning the power steering pump and the fuse feeds the motor.
Current rides:
VW Golf - 83 GT 2.1 16V 2-door with throttles
VW Golf - 78 LS 2.0 8V 4-door (2.1 ABF with throttles in progress)
VW Golf - '08 Citi Storm - 1.4 for now
Hyundai - 1.4 Getz (daily)
VW Golf - 83 GT 2.1 16V 2-door with throttles
VW Golf - 78 LS 2.0 8V 4-door (2.1 ABF with throttles in progress)
VW Golf - '08 Citi Storm - 1.4 for now
Hyundai - 1.4 Getz (daily)
- Gforce
- Cadet
- Posts: 754
- Registered for: 17 years 7 months
- Car Make: VW
- Car Model: Polo 6C 1.2TSI
- Membership No: 1711
- Location: JHB
Re: polo power steering problems
I should have updated, my issue turned out to be a fuse.
________________________________________________
"you can powder coat your arse if you do it right." - MR-D
Current:
2015 Polo 1.2TSI Highline
Ex:
2014 Polo 1.4 Comfortline
2016 Ford Ranger 2.2 XLT Double Cab
2009 A4 2.0T
2004 Golf IV GTi.:R
2003 Golf IV GTI
2006 Fiesta TDCI
2005 Jetta IV 1.8T.:R
2004 Clio Dynamique
2001 Citi Life
"you can powder coat your arse if you do it right." - MR-D
Current:
2015 Polo 1.2TSI Highline
Ex:
2014 Polo 1.4 Comfortline
2016 Ford Ranger 2.2 XLT Double Cab
2009 A4 2.0T
2004 Golf IV GTi.:R
2003 Golf IV GTI
2006 Fiesta TDCI
2005 Jetta IV 1.8T.:R
2004 Clio Dynamique
2001 Citi Life
-
- General
- Posts: 9591
- Registered for: 18 years
- Car Make: VW
- Car Model: Golf GT
- Membership No: 1464
- Location: Springs
Re: polo power steering problems
One off the cases I'm talking about above, the guy had his car at VW and they quoted him R3500 to find the problem and fix it. It took me two minutes and cost nothing, used a spare fuse. This is what bugs ne, VW must be aware of the problem and how easy it is to fix - why R3500?Gforce wrote:I should have updated, my issue turned out to be a fuse.
Current rides:
VW Golf - 83 GT 2.1 16V 2-door with throttles
VW Golf - 78 LS 2.0 8V 4-door (2.1 ABF with throttles in progress)
VW Golf - '08 Citi Storm - 1.4 for now
Hyundai - 1.4 Getz (daily)
VW Golf - 83 GT 2.1 16V 2-door with throttles
VW Golf - 78 LS 2.0 8V 4-door (2.1 ABF with throttles in progress)
VW Golf - '08 Citi Storm - 1.4 for now
Hyundai - 1.4 Getz (daily)
- conzale
- Enlisted
- Posts: 45
- Registered for: 10 years 1 month
- Car Make: vw
- Car Model: polo 6R
- Location: boksburg/bedfordview/brakpan aka BBB.
Re: polo power steering problems
Got a brand new pump from some shop in turfontein only paid 3K for it.
a living dog is better than a dead lion
Ex: 2004 mazda 323 1.6i .
Ex: 2004 mazda 323 1.6i .
-
- Enlisted
- Posts: 2
- Registered for: 8 years 9 months
- Location: KwaZulu Natal
Re: polo power steering problems
What are the chances of my power steering pump given up? It didn't give me any alert prior to this. I just went to fill fuel and switched of the car. When I got back to go off, the steering became extremely heavy and never eased off.
- Gforce
- Cadet
- Posts: 754
- Registered for: 17 years 7 months
- Car Make: VW
- Car Model: Polo 6C 1.2TSI
- Membership No: 1711
- Location: JHB
Re: polo power steering problems
Do yourself a favour and check the fuse first.Caz0410 wrote:What are the chances of my power steering pump given up? It didn't give me any alert prior to this. I just went to fill fuel and switched of the car. When I got back to go off, the steering became extremely heavy and never eased off.
Sent from my GT-I9505 using Tapatalk
________________________________________________
"you can powder coat your arse if you do it right." - MR-D
Current:
2015 Polo 1.2TSI Highline
Ex:
2014 Polo 1.4 Comfortline
2016 Ford Ranger 2.2 XLT Double Cab
2009 A4 2.0T
2004 Golf IV GTi.:R
2003 Golf IV GTI
2006 Fiesta TDCI
2005 Jetta IV 1.8T.:R
2004 Clio Dynamique
2001 Citi Life
"you can powder coat your arse if you do it right." - MR-D
Current:
2015 Polo 1.2TSI Highline
Ex:
2014 Polo 1.4 Comfortline
2016 Ford Ranger 2.2 XLT Double Cab
2009 A4 2.0T
2004 Golf IV GTi.:R
2003 Golf IV GTI
2006 Fiesta TDCI
2005 Jetta IV 1.8T.:R
2004 Clio Dynamique
2001 Citi Life
-
- Enlisted
- Posts: 2
- Registered for: 8 years 9 months
- Location: KwaZulu Natal
Re: polo power steering problems
Thanks GForce. I have found the fuses and have checked them on my TDi. It have a continuity contact. I have replaced the battery, relays and the steering fluid levels haven't moved but topped it up further. No joy as yet.
-
- Cadet
- Posts: 209
- Registered for: 13 years 10 months
- Car Make: Subaru
- Car Model: WRX STi
- Membership No: missing
- Location: GAUTENG
Re: polo power steering problems
Im having this headache now, sent it to bosch to run a diagnostics test and check the fluid levels.
Apparently if i have to replace the power steering itll cost 20k-30k, is this true?
Apparently if i have to replace the power steering itll cost 20k-30k, is this true?
- Jacques1397
- Cadet
- Posts: 659
- Registered for: 9 years 10 months
- Car Make: VW
- Car Model: Citi Rox 1.4i & Golf 5 GTI
- Membership No: 1970
- Location: Nelspruit
Re: polo power steering problems
Had the same issue on my car guys. First it happens from time to time. I then checked earth cable - was corded. Replaced that all fine for a while. Then when the car was stopping on certain angles etc. no power steering. Then power steering went dead completely. All fuses was fine no issues. Then bought a new power steering pump from scrapyard for R5000 and took to the mechanic to replace. Replaced the pump - same story. Eventually took it to the auto electrician to check out. Diagnostic machine don't pick up anything. Turned out to be the electric plug on the steering rack that was dirty and cable a bit damaged. Fixed that - cost me R200 bucks and car is still running 100% up until today
Looks like a common problem on the 9n3's
Looks like a common problem on the 9n3's
Current :
2007 Golf 5 GTI
2008 Citi Rox 1.4i - Daily
Ex :
2009 Polo 1.8t GTI Stage 2
2007 Golf 5 GTI
2008 Citi Rox 1.4i - Daily
Ex :
2009 Polo 1.8t GTI Stage 2
-
- Major
- Posts: 3637
- Registered for: 18 years 7 months
- Car Make: Cheap Ass Porsche
- Car Model: 9N Sooter
- Membership No: 807
- Location: Diep innie bos...
Re: polo power steering problems
So I finally got around to replacing my steering angle sensor cable last week. It runs close to the exhaust and when the engine moves a lot the exhaust can touch this cable and you get this:
The wires are exposed and will short giving you a slightly heavier steering and a nice yellow warning light on the dash.
It is a **** to replace and route through the engine bay if you don't have midget hands but do able none the less.
New cable was R650 from VW
The wires are exposed and will short giving you a slightly heavier steering and a nice yellow warning light on the dash.
It is a **** to replace and route through the engine bay if you don't have midget hands but do able none the less.
New cable was R650 from VW
'04 Polo TDI 1661.9 km on 58.05l
'13 Hyundai Santa Fe 2.2 Elite
'13 Hyundai Santa Fe 2.2 Elite
-
- Cadet
- Posts: 209
- Registered for: 13 years 10 months
- Car Make: Subaru
- Car Model: WRX STi
- Membership No: missing
- Location: GAUTENG
Re: polo power steering problems
Thanks gents,
Bosch ran a diagnostic for me and said they need to check/repair/replace the pump.
Im going to do all the below before they do that and charge me $$$.
1. Earth strap,
2. Fuses
3. Sensor cable,
4. plugs on the pump,
5. Battery
Am i missing something?
Bosch ran a diagnostic for me and said they need to check/repair/replace the pump.
Im going to do all the below before they do that and charge me $$$.
1. Earth strap,
2. Fuses
3. Sensor cable,
4. plugs on the pump,
5. Battery
Am i missing something?
-
- Major
- Posts: 3637
- Registered for: 18 years 7 months
- Car Make: Cheap Ass Porsche
- Car Model: 9N Sooter
- Membership No: 807
- Location: Diep innie bos...
Re: polo power steering problems
What are your symptoms?1FLYCTi wrote:Thanks gents,
Bosch ran a diagnostic for me and said they need to check/repair/replace the pump.
Im going to do all the below before they do that and charge me $$$.
1. Earth strap,
2. Fuses
3. Sensor cable,
4. plugs on the pump,
5. Battery
Am i missing something?
'04 Polo TDI 1661.9 km on 58.05l
'13 Hyundai Santa Fe 2.2 Elite
'13 Hyundai Santa Fe 2.2 Elite
-
- Cadet
- Posts: 209
- Registered for: 13 years 10 months
- Car Make: Subaru
- Car Model: WRX STi
- Membership No: missing
- Location: GAUTENG
Re: polo power steering problems
day 1: 5 seconds the power steering light comes on, steering gets heavy.
day 2: 5 seconds the power steering light comes on, steering gets heavy.
day 3, drive 40km to and from work, no issues,
day 4: drive to work no issues, after work, light stays on for an hour and steering heavy (got the car towed) as soon as i got home, its back to normal.
day 5: no issues
Now its at bosch... they said machine fault code says electrical ( Im waiting for the exact code ) and they want to inspect the pump (R1200-00 just to take it out and look at it )
day 2: 5 seconds the power steering light comes on, steering gets heavy.
day 3, drive 40km to and from work, no issues,
day 4: drive to work no issues, after work, light stays on for an hour and steering heavy (got the car towed) as soon as i got home, its back to normal.
day 5: no issues
Now its at bosch... they said machine fault code says electrical ( Im waiting for the exact code ) and they want to inspect the pump (R1200-00 just to take it out and look at it )
-
- Major
- Posts: 3637
- Registered for: 18 years 7 months
- Car Make: Cheap Ass Porsche
- Car Model: 9N Sooter
- Membership No: 807
- Location: Diep innie bos...
Re: polo power steering problems
1FLYCTi wrote:day 1: 5 seconds the power steering light comes on, steering gets heavy.
day 2: 5 seconds the power steering light comes on, steering gets heavy.
day 3, drive 40km to and from work, no issues,
day 4: drive to work no issues, after work, light stays on for an hour and steering heavy (got the car towed) as soon as i got home, its back to normal.
day 5: no issues
Now its at bosch... they said machine fault code says electrical ( Im waiting for the exact code ) and they want to inspect the pump (R1200-00 just to take it out and look at it )
Sounds like steering angle sensor cable
If it was the pump it would be heavy all the time!
'04 Polo TDI 1661.9 km on 58.05l
'13 Hyundai Santa Fe 2.2 Elite
'13 Hyundai Santa Fe 2.2 Elite